Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 PA-CHAN-GA 		License/Permit #
 KK422
Street Address
110 MEADOWVIEW CENTER
City/State
 KANKAKEE, IL 		ZIP Code
 60901
No. of Risk Factor/Intervention Violations 4
No. of Repeat Risk Factor/Intervention Violations 0
Date 02/07/2024
Time In 11:15 AM
Time Out 02:00 PM
Permit Holder
DEMACK, KATLYN 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected X  
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition X  
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36 X Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41 X Wiping cloths: properly used & stored X  
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43 X In-use utensils: properly stored X  
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45 X Single-use/single-service articles: properly stored & used X  
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54 X Garbage & refuse properly disposed; facilities maintained    
55 X Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57 X All food employees have food handler training    
58 X Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: PA-CHAN-GA Establishment #: KK422
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: CHLORINE: 0 - 50 Heat: N/A °F
CFPM Verification (name, ID#, expiration date):
TERRI WESTFALL
K5CKB-IKCHKJF
08/03/2026 		NOE SERNA
1615155
08/18/2027 		RAMON DIAZ
1615140
08/18/2027

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
fish/frigidaire clr/fzr combo #1 - main prep line 38.00°F /frigidaire clr/fzr combo #1 - main prep line -1.00°F rice; beans; red sauce/warming table at main prep line 165.00°F
diced tomatoes; beef/reach-in cooler/prep-table at main prep line 39.00°F ground beef/cooked on stove (boiled) 205.00°F rice/held on stove top 175.00°F
chicken and beef/cooked on grill 185.00°F /stand-up freezer - dry storage -1.00°F /walk-in freezer -1.00°F
/bar coolers (3x) 38.00°F cut lemons/walk-in cooler behind bar 38.00°F  

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
10 C 6-301.14: A sign or poster that notifies FOOD EMPLOYEES to wash their hands shall be provided at all HANDWASHING SINKS used by FOOD EMPLOYEES and shall be clearly visible to FOOD EMPLOYEES.
violation: no hand washing signage within the public restrooms and at the kitchen's handwashing station. corrective action required: install hand washing signage at hand washing stations. correct by the next routine inspection.
15 P 3-304.11 (A) (B) (C): FOOD shall only contact surfaces of: (A) EQUIPMENT and UTENSILS that are cleaned as specified under Part 4-6 of this Code and SANITIZED as specified under Part 4-7 of this Code;  (B) SINGLE-SERVICE and SINGLE-USE ARTICLES; or (C) LINENS, such as cloth napkins, as specified under § 3-304.13 that are laundered as specified under Part 4-8 of this Code.  
violation: at the reach-in cooler/prep-table located at the main cook line, raw animal products, including raw chicken and raw beef were stored next to each other. corrective action taken: raw animal products were separated (chicken placed on the bottom shelf. COS
16 PF 4-501.114 (F) (3-4): A chemical SANITIZER used in a SANITIZING solution for a manual or mechanical operation at contact times specified under ¶4-703.11(C) shall meet the criteria specified under §7-204.11 Sanitizers, Criteria, shall be used in accordance with the EPA- registered label use instructions, and shall be used as follows: (F) If a chemical SANITIZER is generated by a device located on-site at the FOOD ESTABLISHMENT it shall be used as specified in ¶¶(A) - (D) of this section and shall be produced by a device that:  (3) Displays the EPA device manufacturing facility registration number on the device, and (4) Is operated and maintained in accordance with manufacturer’s instructions.
violation: dishwasher rinse cycle is not dispensing the sanitizer at the proper level (0 - 10 PPM for a hypochlorite sanitizer). corrective action required: repair and maintain dishwasher. - (Correct By: Feb 10, 2024)
23 PF 3-501.17 (A-B) (E-G): (A)Except when PACKAGING FOOD using a REDUCED OXYGEN PACKAGING method as specified under § 3-502.12, and except as specified in ¶¶ (E) and (F) of this section, refrigerated, READY-TO -EAT, TIME/TEMPERATURE CONTROL FOR SAFETY FOOD prepared and held in a FOOD ESTABLISHMENT for more than 24 hours shall be clearly marked to indicate the date or day by which the FOOD shall be consumed on the PREMISES, sold, or discarded when held at a temperature of 5ºC (41ºF) or less for a maximum of 7 days. The day of preparation shall be counted as Day 1. (B) Except as specified in ¶¶ (E) - (G) of this section, refrigerated, READY-TO-EAT TIME/TEMPERATURE CONTROL FOR SAFETY FOOD prepared and PACKAGED by a FOOD PROCESSING PLANT shall be clearly marked, at the time the original container is opened in a FOOD ESTABLISHMENT and if the FOOD is held for more than 24 hours, to indicate the date or day by which the FOOD shall be consumed on the PREMISES, sold, or discarded, based on the temperature and time combinations specified in ¶ (A) of this section and: (1) The day the original container is opened in the FOOD ESTABLISHMENT shall be counted as Day 1; and (2) The day or date marked by the FOOD ESTABLISHMENT may not exceed a manufacturer’s use-by date if the manufacturer determined the use-by date based on FOOD safety. (E) Paragraphs (A) and (B) of this section do not apply to individual meal portions served or rePACKAGED for sale from a bulk container upon a consumer’s request. (F) Paragraphs (A) and (B) of this section do not apply to SHELLSTOCK.  (G) Paragraph (B) of this section does not apply to the following FOODS prepared and PACKAGED by a FOOD PROCESSING PLANT inspected by a REGULATORY AUTHORITY: (1) Deli salads, such as ham salad, seafood salad, chicken salad, egg salad, pasta salad, potato salad, and macaroni salad, manufactured in accordance with 21 CFR 110 Current good manufacturing practice in manufacturing, packing, or holding human food; (2) Hard cheeses containing not more than 39% moisture as defined in 21 CFR 133 Cheeses and related cheese products, such as cheddar, gruyere, parmesan and reggiano, and romano; (3) Semi-soft cheeses containing more than 39% moisture, but not more than 50% moisture, as defined in 21 CFR 133 cheeses and related cheese products, such as blue, edam, gorgonzola, gouda, and monterey jack; (4) Cultured dairy products as defined in 21 CFR 131 Milk and cream, such as yogurt, sour cream, and buttermilk; (5) Preserved FISH products, such as pickled herring and dried or salted cod, and other acidified FISH products defined in 21 CFR 114 Acidified foods; (6) Shelf stable, dry fermented sausages, such as pepperoni and Genoa; and (7) Shelf stable salt-cured products such as prosciutto and Parma (ham).
violation: within the walk-in cooler, several prepped food items did not have any labeling information, including cooked chicken, salsa, and beans. corrective action taken: all products were labeled with a use-by date. COS
36 PF 4-204.112 (B-C): (B) Except as specified in¶(C) of this section, cold or hot holding EQUIPMENT used for TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be designed to include and shall be equipped with at least one integral or permanently affixed TEMPERATURE MEASURING DEVICE that is located to allow easy viewing of the device's temperature display. 4-204.112 Temperature Measuring Devices.(C) Paragraph (B) of this section does not apply to EQUIPMENTfor which the placement of a TEMPERATURE MEASURING DEVICE is not a practical means for measuring the ambient air surrounding the FOOD because of the design, type, and use of the EQUIPMENT, such as calrod units, heat lamps, cold plates, bainmaries, steam tables, insulated FOOD transport containers, and salad bars.
violation: no thermometer within the cookline's cooler/freezer combo unit. corrective action require: installed thermometer within the unit.
41 C 3-304.14 (B)(1)(2): (B) Cloths in-use for wiping counters and other EQUIPMENT surfaces shall be: (1) Held between uses in a chemical sanitizer solution at a concentration specified under § 4-501.114; and (2) Laundered daily as specified under ¶ 4-802.11(D).
violation: wiping cloth used to wipe down the cutting board installed at the prep cooler/table at the main cook line was stored on the cutting board. corrective action taken: the wiping cloth was moved to the sanitizer bucket. COS
43 C 3-304.12 (B): During pauses in FOOD preparation or dispensing, FOOD preparation and dispensing UTENSILS shall be stored: (B) In FOOD that is not TIME/TEMPERATURE CONTROL FOR SAFETY FOOD with their handles above the top of the FOOD within containers or EQUIPMENT that can be closed, such as bins of sugar, flour, or cinnamon.
violation: within the rice bag at the dry storage space and the spice container located in the kitchen, the scoop handles were found touching the food product. corrective action taken: the product's scoops were replaced with equipment and the handles were found up and out of the products. COS
45 C 4-903.11( A)(1)(2)(3): (A) Except as specified in ¶ (D) of this section, cleaned EQUIPMENT and UTENSILS, laundered LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES shall be stored: (1) In a clean, dry location; (2) Where they are not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor.
violation: within the dry storage space, one box of food containers and one box of plastic cups were found stored on the ground. corrective action taken: boxes were moved to storage shelves. COS
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
violation: warming wells for the warming table and the portable table-top warmer are unclean. corrective action required: clean and maintain equipment by the next routine inspection.
54 C 5-501.115: A storage area and enclosure for REFUSE, recyclables, or returnables shall be maintained free of unnecessary items, as specified under § 6-501.114, and clean.
violation: excess garbage found around exterior enclosure. corrective required: clean and maintain exterior enclosure by the next routine inspection.
55 C 6-501.11: PHYSICAL FACILITIES shall be maintained in good repair.
violation: several wall tiles within the dry storage area/corridor is missing or broken. In addition, a wall panel is not properly secured around the dishwasher. furthermore, the door to the walk-in freezer is broken. corrective action required: repair wall tiles and panels. Also, repair walk-in freezer door. Repair work shall be completed by the next routine inspection.
 

Person In Charge

  NOE SERNA 		 

Date:

  02/07/2024
 

Inspector

  Alan Hatia 		 

Follow-up:  Yes   No   Follow-up Date:

02/12/2024

Food Establishment Inspection Report
Page 3  of ?????? 
Establishments: PA-CHAN-GA Establishment #: KK422

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
55 C 6-501.114: The PREMISES shall be free of: (A) Items that are unnecessary to the operation or maintenance of the establishment such as EQUIPMENT that is nonfunctional or no longer used; and (B) Litter.
violation: observed unused equipment in the storage room located near the kitchen's back exit. corrective action required: reduce clutter by the next routine inspection.
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
violation: the walk-in cooler's floor is unclean. corrective action required: clean and maintain floor by the next routine inspection. In addition, the floor section under storage shelves within the dry storage space is unclean. corrective action required: clean and maintain floors by the next routine inspection.
57 violation: one employee has not completed basic food handler training. corrective action required: have all employees tasked with handling food complete basic food handler training. - (Correct By: Mar 8, 2024)
58 C violation: the certified food protection managers have not completed allergen training. corrective action required: all workers holding the CFPM certificate shall complete allergen training. correct by the next routine inspection.
Inspection Comments   ORIGINAL INSPECTION WAS CONDUCTED ALONGSIDE A COMPLAINT INVESTIGATION (SEE COMPLAINT REPORT FOR MORE INFORMATION).
HACCP Topic: PROPER HANDLING OF READY-TO-EAT FOOD ITEMS: NO BARE HAND CONTACT ALLOWED; USE GLOVES OF UTENSILS.
 

Person In Charge

  NOE SERNA 		 

Date:

  02/07/2024
 

Inspector

  Alan Hatia 		 

Follow-up:  Yes   No   Follow-up Date:

02/12/2024